Show Notes
The DC-10 was McDonnell Douglas’s first commercial airliner project since the merger between McDonnell Aircraft Corporation and the Douglas Aircraft Company in 1967. It started life on the drawing boards as a 4 engined, double decked, wide body airliner that could carry 550 passengers but morphed into single deck, three engined aircraft that could carry one passenger short of 400! In what was expected to be a knockout blow to the competing Lockheed L-1011, the President of American Airlines and James McDonnell of McDonnell Douglas announced American Airlines’ intention to acquire the DC-10. Flight 96 was en route between Detroit and Buffalo when, above the city of Windsor in Ontario whilst climbing through 11,750 ft the flight crew heard a distinct thud and dirt and debris flew up from the cockpit floor into their faces. On inspection it was obvious that the rear cargo door had detached from the aircraft. This is the story of the DC-10 cargo door issue and the engineer who tried to warn the company of the dire problem.
The 4 Engined Douglas Proposal
The DC-10
The Cargo Door
The Cargo Door of Flight 96
The Accident Report of Turkish Airlines Flight 981
Images under Creative Commons licence with thanks to the SDASM archives, the Douglas Aircraft Corp, U.S. National Archives and Records Administration, the FAA and the DOT AIB.
More from Plane Tales
With the influx of new Airbus airframes, Virgin needed more pilots and not just to occupy the right hand seat… there were opportunities for promotion to Captain much earlier than had been the norm. When I joined the time to command was about 8 years. Looking back I did my first sector with Virgin in July 1994 and it was now November 96, 2 years 4 months later and I was already starting my pre-command training.
We last spoke to Basam when he was doing his Jet Upset Training but now that he has his dream job it was appropriate that we should chat again on one of his London layovers. In particular, he is flying around a war zone which presents additional challenges to a civil airline pilot.
A flock of seagulls had chosen that moment to break ground from the grass beside the runway and fly across our path. They disappeared under the nose as we climbed away and cleaned the aircraft up… no noise of an impact but then we noticed the No 2 engine’s N1 vibration number was pulsing and reading a bit high. So starts another Tale from my flying logbook.
The next tale from my RAF Logbook, albeit now being filled with civilian flights for Virgin Atlantic Airways…